淺談端子壓接區膜層對安全氣囊系統的影響
【摘 要】本文簡單介紹安全氣囊系統的構成與原理,對故障車及零部件進行多種檢測,根據檢測結果對氣囊回路阻值高的問題進行深入分析,最終確定端子壓接區形成的膜層導致回路阻值異常,為從源頭上解決該問題提供依據。由于裝配不當造成的線路異常、零部件損壞等原因造成的故障不在本文討論范圍。
【關鍵詞】安全氣囊;高阻值;線束;端子壓接;膜層
中圖分類號:U463.62 文獻標志碼:A 文章編號:1003-8639( 2022 )07-0042-04
The Influence of the Film in the Terminal Crimping Area on the SRS
YUE Ben-long
(Beijing Automotive Technology Center,Beijing 100029,China)
【Abstract】Vehicles often report high resistance fault of SRS,which is eliminated after maintenance,but the fault reappears after a period of time,and the root cause cannot be found. This paper briefly describes the composition and principle of the SRS,carries out various tests on the faulty vehicle and parts,deeply analyzes the problem of high resistance of the SRS according to the test results,and finally determines that the film formed in the terminal crimping area leads to the high resistance of the circuit,which provides a basis for solving the problem from the source. The faults caused by improper assembly,such as abnormal circuit and damage of parts and components,are not discussed in this paper.
【Key words】SRS;high resistance;wire harness;terminal crimping;film
作者簡介 岳本龍(1981—),男,工程師,主要負責特種車輛系統集成工作。(剩余6155字)
- 新會員:廣州市鵬云工程塑料有限...
- 天海之路,唯創新不可辜負...
- 廈門市委副書記張毅恭蒞臨海普銳...
- 基于模型預測的智能汽車軌跡跟蹤...
- 車路協同下的基于S函數的交叉口...
- 電動汽車動力域控制器設計研究...
- 電動汽車換電技術分析及標準化發...
- 基于商用車氣剎特性的混合動力制...
- 混合動力汽車電池包液冷板冷卻性...
- 純電動客車空調結構布局設計探討...
- 基于Aspice與ISO 26...
- 淺析汽車電源管理系統研究及運用...
- CAN波形診斷技術在整車通信故...
- 汽車車燈集成激光雷達的應用研究...
- 基于C#的AutoCAD二次開...
- 一種通過負載狀態預估高壓繼電器...
- 淺談端子壓接區膜層對安全氣囊系...
- CANFD協議在故障診斷中的研...
- 汽車線束智能制造關鍵技術研究及...
- 連接器常見失效類型及原因分類分...
- GNSS抑制多徑技術研究進展...
- 基于多信息融合的汽車電子系統故...
- 基于ISO 13400標準的通...
- 后視鏡投影燈缺陷分析及改善方案...
- 鼓風機繼電器失效分析...
- 某輕型卡車空調降溫性能的改進...
- 關于量產車型白車身溢膠問題的分...
- 發動機用主電子水泵電容失效問題...
- 某車型CVT變速器嘯叫排查及解...
- 基于CAPL語言的車輛下線電氣...
- 基于CAPL編程的CAN網絡仿...
- 環境溫度對整車起動阻力矩的影響...
- 基于CANoe MQTT節點仿...
- 汽車低壓電源不發電情況下的駕車...
- 論底盤測功機在整車緩速器冷卻性...
- 多功能小型移動試驗平臺...
- ECU電磁兼容試驗用負載和監控...
- 卡車制造端的電氣故障分析與排除...
- 寶馬118i發動機異常抖動故障...
- 乘用車座椅加熱模塊電檢問題的研...